|
Last Modified: 05-08-2025 |
6.11:8.1.0 |
Doc ID: RM100000001GIKR |
|
Model Year Start: 2019 |
Model: RAV4 |
Prod Date Range: [11/2018 - 10/2019] |
|
Title: BRAKE SYSTEM (OTHER): BRAKE PEDAL (w/ Vacuum Brake Booster): REMOVAL; 2019 MY RAV4 RAV4 HV [11/2018 - 10/2019] |
REMOVAL
CAUTION / NOTICE / HINT
The necessary procedures (adjustment, calibration, initialization or registration) that must be performed after parts are removed and installed, or replaced during brake pedal support assembly removal/installation are shown below.
Necessary Procedures After Parts Removed/Installed/Replaced
|
Replaced Part or Performed Procedure
|
Necessary Procedure
|
Effect/Inoperative Function when Necessary Procedure not Performed
|
Link
|
|
Battery terminal is disconnected/reconnected
|
Drive the vehicle until stop and start control is permitted (approximately 5 to 60 minutes)
|
Stop and start system
|
|
|
Perform steering sensor zero point calibration
|
Lane control system
|
|
|
Parking support brake system (for Gasoline model)*
|
|
Pre-collision system
|
|
Memorize steering angle neutral point
|
Parking assist monitor system
|
|
|
Panoramic view monitor system (for Gasoline model)
|
|
|
Reset back door close position
|
Power back door system (for Gasoline model)
|
|
|
Back door lock initialization
|
Power door lock control system
|
|
|
Replacement of brake actuator assembly
|
Operate the electric parking brake switch assembly
|
Parking brake indicator light blinks when the engine switch is first turned on (IG)
|
|
|
Perform system variant learning and acceleration sensor zero point calibration
|
-
VSC is disabled or malfunctions
-
DTCs are output
-
Slip indicator light illuminates
-
ABS warning light illuminates
|
|
NOTICE:
After the ignition switch is turned off, the radio and display receiver assembly records various types of memory and settings. As a result, after turning the ignition switch off, be sure to wait for the time specified in the following table before disconnecting the cable from the negative (-) battery terminal.
Waiting Time before Disconnecting Cable from Negative (-) Battery Terminal
|
System Name
|
See Procedure
|
|
Vehicle enrolled in Toyota Entune system or safety connect system
|
6 minutes
|
|
Vehicle not enrolled in Toyota Entune system and safety connect system
|
1 minute
|
PROCEDURE
1. PRECAUTION
CAUTION:
Be sure to read precaution thoroughly before servicing.
-
w/ Occupant Classification System:
Click here
-
w/o Occupant Classification System:
Click here
NOTICE:
After turning the ignition switch off, waiting time may be required before disconnecting the cable from the negative (-) auxiliary battery terminal. Therefore, make sure to read the disconnecting the cable from the negative (-) auxiliary battery terminal notices before proceeding with work.
Click here
2. REMOVE LOWER NO. 1 INSTRUMENT PANEL AIRBAG ASSEMBLY
Click here
3. REMOVE NO. 1 AIR DUCT (for TMC Made)
Click here
4. REMOVE NO. 2 AIR DUCT SUB-ASSEMBLY (for TMMC Made)
Click here
5. REMOVE STOP LIGHT SWITCH ASSEMBLY
Click here
6. REMOVE STOP LIGHT SWITCH MOUNTING ADJUSTER
Click here
7. DISCONNECT BRAKE PEDAL SUPPORT ASSEMBLY
|
(a) Disconnect the connector and disengage the 2 clamps.
|
|
|
(b) Remove the bolt and disconnect the brake pedal support assembly from the instrument panel reinforcement assembly.
|
|
8. REMOVE BRAKE PEDAL RETURN SPRING
|
(a) Remove the brake pedal return spring from the brake pedal support assembly.
|
|
9. REMOVE INSTRUMENT PANEL REINFORCEMENT ASSEMBLY WITH AIR CONDITIONING UNIT ASSEMBLY
Click here
10. REMOVE PUSH ROD PIN
|
(a) Remove the clip and push rod pin.
|
|
11. REMOVE BRAKE PEDAL SUPPORT ASSEMBLY
|
(a) w/ clip:
(1) Remove the 2 clips from the brake pedal support assembly.
|
|
|
(b) Remove the 4 nuts and brake pedal support assembly.
|
|
12. REMOVE BRAKE PEDAL PAD
(a) Remove the brake pedal pad from the brake pedal support assembly.
|